Volume 15, Number 1—January 2009
Sphingomonas paucimobilis Bloodstream Infections Associated with Contaminated Intravenous Fentanyl1
Nationally distributed medications from compounding pharmacies, which typically adhere to less stringent quality-control standards than pharmaceutical manufacturers, can lead to multistate outbreaks. We investigated a cluster of 6 patients in a Maryland hospital who had Sphingomonas paucimobilis bloodstream infections in November 2007. Of the 6 case-patients, 5 (83%) had received intravenous fentanyl within 48 hours before bacteremia developed. Cultures of unopened samples of fentanyl grew S. paucimobilis; the pulsed-field gel electrophoresis pattern was indistinguishable from that of the isolates of 5 case-patients. The contaminated fentanyl lot had been prepared at a compounding pharmacy and distributed to 4 states. Subsequently, in California, S. paucimobilis bacteremia was diagnosed for 2 patients who had received intravenous fentanyl from the same compounding pharmacy. These pharmacies should adopt more stringent quality-control measures, including prerelease product testing, when compounding and distributing large quantities of sterile preparations.
Compounding pharmacies are licensed or registered by state pharmacy boards to combine “reasonable quantities” of ingredients to fill a valid prescription from a licensed practitioner for an individual patient (1). Some pharmacies, however, have moved beyond this role and, in anticipation of receiving routine orders, prepare larger quantities of compounded preparations for national distribution to healthcare facilities (2,3). Nationally distributed medications from compounding pharmacies, which typically adhere to less stringent quality-control standards than pharmaceutical manufacturers, can lead to multistate outbreaks that may be difficult to detect. Sunenshine et al. recently reported a 5-state outbreak of Serratia marcescens bloodstream infections associated with contaminated intravenous magnesium sulfate from a compounding pharmacy (3). Other reported outbreaks caused by contaminated medications from compounding pharmacies include the following: S. marcescens infections associated with betamethasone injection, Pseudomonas putida septicemia caused by use of contaminated flush solutions in a special-care nursery, Burkholderia cepacia infections caused by contaminated intravenous flush solutions, Pseudomonas fluorescens bloodstream infections associated with a heparin/saline flush, and Exophiala dermatitidis infections caused by injection of contaminated steroids (4–10; Table 1).
Sphingomonas paucimobilis is an aerobic bacterium found in soil and water; it is a rare cause of healthcare-associated infections (11,12). S. paucimobilis has been reported to cause outbreaks of bacteremia among immunocompromised patients in hematology and oncology units; these outbreaks are possibly related to bacterial colonization of hospital water systems (13,14). An S. paucimobilis outbreak in mechanically ventilated neonates was linked to contaminated temperature probes (15). In November 2007, The Johns Hopkins Hospital Department of Hospital Epidemiology and Infection Control initiated an outbreak investigation after being notified by the hospital’s microbiology laboratory of the growth of S. paucimobilis in several patients’ blood cultures over a 2-week period.
The Johns Hopkins Hospital is a 926-bed, tertiary-care, academic hospital in Baltimore, Maryland, USA. For this investigation, we defined a case-patient as any patient in our hospital whose cultures of blood or of other normally sterile body sites grew S. paucimobilis in November 2007. S. paucimobilis isolates were characterized as gram-negative rods that are yellow-pigmented, glucose nonfermenting, and weakly oxidase positive; they were preliminarily identified by the BD Phoenix Automated Microbiology System (BD Diagnostics, Inc. Sparks, MD, USA). All S. paucimobilis isolates were confirmed by cell wall fatty acid analysis using gas liquid chromatography (Sherlock Microbial Identification System version 4.5, library 5.0; MIDI, Inc. Newark, DE, USA). Microbiology records from January 2006 through November 2007 were examined to identify case-patients and to establish the baseline rate of S. paucimobilis bacteremia. We identified common exposures for case-patients and focused on intravenous infusions, medications, and contrast agents and on case-patients’ clinical signs, treatments, and outcomes. Because most of the blood cultures growing S. paucimobilis were collected in BacT/Alert FA bottles containing activated charcoal (bioMérieux, Durham, NC, USA), we cultured noninoculated bottles from clinical units by placing them directly into the blood culture instrument to assess for intrinsic contamination. On the basis of information from the medical record review, samples for bacterial culture were taken from 4 implicated lots of intravenous fentanyl mixed in 0.9% sodium chloride solution. All 4 lots came from an out-of-state compounding pharmacy, hereafter called pharmacy A. All S. paucimobilis isolates were strain typed by pulsed-field gel electrophoresis (PFGE) after digestion with XbaI using standard methods and interpreted according to criteria established by Tenover et al. (16).
We investigated the possibility that fentanyl had been tampered with or diverted by tracing the narcotic chain of custody, reviewing controlled substance procedures, visually inspecting fentanyl bags for signs of tampering, testing fentanyl concentrations, and analyzing personnel access records from the automated medication management system (Pyxis, Cardinal Health; www.cardinal.com/us/en/providers/products/pyxis/index.asp). The investigation was coordinated with public health authorities, including the Centers for Disease Control and Prevention (CDC) and the Baltimore City Health Department. CDC performed a multistate case-finding investigation by working with the compounding pharmacy to trace the distribution of implicated lots of intravenous fentanyl and by asking recipient healthcare institutions whether they had identified cases of S. paucimobilis bacteremia. We notified the US Food and Drug Administration (FDA) of our findings, and the FDA investigated compounding practices at pharmacy A. The Johns Hopkins University Institutional Review Board approved this study and waived informed consent.
S. paucimobilis was isolated from the blood cultures of 6 patients; the samples were collected from November 11 through November 23, 2007. The organism was not isolated from cultures of any other body site. Case-patients had various underlying medical conditions and had been admitted to different hospital units: neurologic intensive care unit (3 patients), medical intensive care unit (1 patient), oncology center (1 patient), and medicine unit (1 patient) (Table 2). S. paucimobilis grew in multiple sets of blood cultures (5 patients) and from blood cultures collected on >1 date (3 patients). In the preceding 22 months, S. paucimobilis had been isolated from blood cultures of 4 patients (Figure 1). As a result of S. paucimobilis bloodstream infections, 5 of the case-patients reported here received antimicrobial drug treatment and had central intravenous catheters or implanted medication ports removed and replaced. One of these patients had an adverse reaction (rash and renal insufficiency) to antimicrobial drug treatment. All 5 patients treated with antimicrobial agents became free of S. paucimobilis bloodstream infection and survived. One patient (patient 5, Table 2) died of group A streptococcal sepsis before blood culture results for S. paucimobilis were available.
No breaches of infection control procedures or inappropriate blood culture practices were identified. Blood for culture was collected by staff in each unit rather than by a central vascular access team. No growth occurred from cultures of 50 noninoculated activated charcoal blood culture bottles; this finding was therefore not consistent with a pseudo-outbreak or intrinsic contamination of the bottles. Pharmacy records showed that 5 (83%) of 6 case-patients had received at least 1 intravenous dose of fentanyl (10 μg/mL in 250 mL 0.9% sodium chloride) within the 48 hours before S. paucimobilis bacteremia developed. No other common exposure was identified. We found that our hospital had outsourced preparation of 250-mL fentanyl bags to pharmacy A, which shipped several lots to the hospital every 2 weeks.
Cultures of unopened samples from 1 implicated fentanyl lot grew S. paucimobilis that had a PFGE pattern indistinguishable from that of the isolates of the 5 patients who had received intravenous fentanyl (Figure 2). A sixth case-patient (patient 1; Table 2), who did not receive intravenous fentanyl, had S. paucimobilis with a unique PFGE pattern. Of 26 unopened bags from the implicated lot of fentanyl that were cultured, 16 (62%) grew S. paucimobilis. Cultures of 9 samples from 3 other fentanyl lots in use during the outbreak period produced no growth.
CDC’s multistate case-finding investigation determined that pharmacy A had distributed the contaminated fentanyl lot to 4 hospitals in different states. A California hospital that had received the implicated lot subsequently identified 2 additional case-patients who had S. paucimobilis bacteremia after administration of intravenous fentanyl from pharmacy A (Table 2). After diagnosis of bacteremia, these 2 case-patients received treatment with appropriate antimicrobial drugs without removal of existing central lines and were subsequently discharged from the hospital without complications from the bacteremia. At the California hospital, no unopened bags of the implicated fentanyl lot were available for culture, and the bloodstream isolates were not available for PFGE analysis. Specific lot numbers of fentanyl administered to patients were not available at either hospital. The 2 other hospitals that had received the implicated fentanyl lot did not detect any case-patients. The outbreak ended after the implicated fentanyl lot was removed from clinical areas. All bags of the implicated lot that could be located were tested for sterility at The Johns Hopkins Hospital and CDC before being discarded. The rest of the lot had either been used or was expired and destroyed. No product was recalled by pharmacy A.
Investigation found no evidence of tampering with or diversion of fentanyl within the Maryland hospital. We found stringent procedures in place to document and secure the narcotic chain of custody. No signs of tampering were visible on implicated bags of fentanyl that later grew S. paucimobilis, and the bags contained the expected concentration of fentanyl. We found that it was possible, although difficult, to remove and replace safety seals on the bags, which potentially could allow diversion of fentanyl without visible signs of tampering. Analysis of personnel access records from the automated medication and supply management system (Pyxis, Cardinal Health) did not identify any 1 person who had accessed >1 of the machines where the fentanyl was stored in the 4 hospital units with case-patients.
These 250-mL bags of intravenous fentanyl in 0.9% sodium chloride solution (10 μg/mL) are currently available only from pharmacy A and 1 other out-of-state compounding pharmacy. This preparation is the most frequently used at our institution and is not available from any pharmaceutical manufacturer. Because commercially available opioid alternatives at the desired concentration are not available, and to avoid disruption of patient care, our hospital continued to purchase the compounded preparation from pharmacy A. For 3 months after the outbreak, our microbiology laboratory performed sterility testing by culturing samples from each fentanyl lot received. None of these samples grew any bacterial or fungal pathogens. We do not have access to the results of FDA’s investigation into compounding practices at pharmacy A.
We describe a multistate outbreak of S. paucimobilis bacteremia that was associated with contaminated intravenous fentanyl prepared at an out-of-state compounding pharmacy. Astute observation by microbiology laboratory staff, good communication, and swift implementation of an epidemiologic investigation led to expeditious characterization of the source of the infections and termination of the outbreak. Pharmacy A prepares large quantities of compounded pharmaceutical preparations and distributes them to many states in anticipation of orders. In contrast to pharmaceutical manufacturers, traditional compounding pharmacies are not routinely inspected by FDA to ensure that they have the capacity to consistently produce high-quality drugs. In response to other infectious outbreak incidents, the FDA has warned compounding pharmacies that the high-volume production of pharmaceutical preparations in response to bulk orders constitutes manufacturing and is inconsistent with traditional pharmacy compounding (17,18). Current good manufacturing practice regulations, as defined by FDA, require end-product sterility testing, among other stringent controls, when sterile pharmaceutical products are manufactured (19). Although traditional pharmacy compounding fills a commercial void when FDA-approved, commercially available drugs cannot meet patients’ medical needs, the lack of end-product sterility testing and other standards of good manufacturing practice is a serious potential threat to patient safety when compounding pharmacies produce and distribute large quantities of sterile pharmaceutical preparations. Multistate distribution of compounded preparations makes outbreaks and clusters of infections even more difficult to detect and manage.
In 2001, as a result of a dispute over advertising restrictions, the Supreme Court ruled that the compounding provisions of the FDA Modernization Act of 1997 were unconstitutional (20–22). In 2002, the FDA issued guidance to clarify the FDA’s position on pharmaceutical compounding; the guidance identified factors that are considered in deciding whether to initiate enforcement action with respect to compounding (1). FDA historically has not taken enforcement actions against pharmacies engaged in traditional pharmacy compounding, but it has directed its enforcement against establishments whose activities are normally associated with a drug manufacturer. However, much of the investigation, regulation, and enforcement of compounding falls to state licensing boards (2,18). The American Society of Health-System Pharmacists (ASHP), the United States Pharmacopeia (USP), and the National Association of Boards of Pharmacy have issued practice and quality assurance guidelines for sterile compounding of pharmaceutical preparations (23,24). In 2004, USP chapter 797 put forth a set of enforceable standards for the compounding of sterile preparations (25); recently revised standards took effect on June 1, 2008 (24). These standards do not require end-product sterility testing for most compounded preparations (24). Some states require compounding pharmacies to comply with USP 797 and ASHP standards; however, a national survey found that many pharmacies are not fully compliant with ASHP quality assurance guidelines (26), and a 2006 survey documented incomplete awareness and implementation of USP 797 standards (27). From 1990 through 2002, the FDA received reports of >55 quality problems associated with compounded preparations (28); Table 1 shows reports of 6 such incidents published since 2002. An FDA survey in 2001 found 34% of tested preparations from compounding pharmacies failed to meet analytic testing standards, although none failed sterility tests (28).
Our investigation had limitations. Neither hospital could trace the lot numbers administered to each patient, so we could neither confirm which patients received contaminated lots of fentanyl nor assess an attack rate for receipt of the contaminated lots. We did not conduct a case–control study to calculate an odds ratio for administration of fentanyl being the primary risk factor for infection. Isolates from California case-patients were not available for strain typing. Finally, we do not have access to FDA’s investigational findings regarding pharmacy A, which might indicate the source of the contamination. Despite these limitations, the available evidence strongly suggests that contaminated fentanyl from pharmacy A was the source of this multistate outbreak of S. paucimobilis bloodstream infections.
FDA continues to face many serious and complex challenges (29,30). Our investigation, along with other similar published reports, indicates that the issue of large-scale pharmaceutical production and distribution by compounding pharmacies is also an urgent concern that requires attention. Pharmacies that compound and distribute large quantities of sterile pharmaceutical preparations without prescriptions for individual patients should be considered manufacturers and should be required to follow good manufacturing practices, including end-product sterility testing.
Until stricter regulations are imposed and enforced, hospital pharmacists and administrators must be cautious when outsourcing compounded pharmaceutical preparations and should consider the possibility of contaminated sterile pharmaceutical products when unusual organisms or patterns of disease are detected. Hospital personnel may be unaware that preparation of pharmaceutical products has been outsourced to a compounding pharmacy (3) and may not recognize the different regulatory requirements and potential implications of this decision. Healthcare facilities should strongly consider recording lot numbers of compounded medications administered to individual patients because this would aid investigations. Increased outsourcing of compounded pharmaceutical preparations makes surveillance for unexpected untoward events increasingly important. Compounding pharmacies should adhere to the standards set forth in USP 797 and should adopt more stringent quality control measures, including prerelease product testing, when preparing and distributing large quantities of sterile preparations.
Dr Maragakis is an assistant professor of medicine in the Division of Infectious Diseases at the Johns Hopkins University School of Medicine. She is also an associate hospital epidemiologist at The Johns Hopkins Hospital. Her research interest is healthcare-associated gram-negative infections.
We thank Beryl Rosenstein, Margaret Garrett, Jeff Natterman, Alex Shangraw, Ernest Feroli, Teresa Wakefield, Kimberly Eskey, Mark Romagnoli, and members of the Microbiology Laboratory, Risk Management, Facilities, Pharmacy, and Security Departments of The Johns Hopkins Hospital; we also thank Laura Herrera, Mary Grace Munoz, and David Blythe.
L.L.M. was supported by grants 1 K01 CI000300 and 1 R01 CI000530 from the Centers for Disease Control and Prevention.
- US Food and Drug Administration. Guidance for FDA staff and industry compliance policy guides manual; section 460.200; pharmacy compounding; 2002 [cited 2008 Mar 28]. Available from http://www.fda.gov/OHRMS/DOCKETS/98fr/02D-0242_gdl0001.pdf
- Pegues DA. Improving and enforcing compounding pharmacy practices to protect patients. Clin Infect Dis. 2006;43:838–40.
- Sunenshine RH, Tan ET, Terashita DM, Jensen BJ, Kacica MA, Sickbert-Bennett EE, A multistate outbreak of Serratia marcescens bloodstream infection associated with contaminated intravenous magnesium sulfate from a compounding pharmacy. Clin Infect Dis. 2007;45:527–33.
- Civen R, Vugia DJ, Alexander R, Brunner W, Taylor S, Parris N, Outbreak of Serratia marcescens infections following injection of betamethasone compounded at a community pharmacy. Clin Infect Dis. 2006;43:831–7.
- Perz JF, Craig AS, Stratton CW, Bodner SJ, Phillips WE Jr, Schaffner W. Pseudomonas putida septicemia in a special care nursery due to contaminated flush solutions prepared in a hospital pharmacy. J Clin Microbiol. 2005;43:5316–8.
- Held MR, Begier EM, Beardsley DS, Browne FA, Martinello RA, Baltimore RS, Life-threatening sepsis caused by Burkholderia cepacia from contaminated intravenous flush solutions prepared by a compounding pharmacy in another state. Pediatrics. 2006;118:e212–5.
- Patel PR, Larson AK, Castel AD, Ganova-Raeva LM, Myers RA, Roup BJ, Hepatitis C virus infections from a contaminated radiopharmaceutical used in myocardial perfusion studies. JAMA. 2006;296:2005–11.
- Centers for Disease Control and Prevention. Pseudomonas bloodstream infections associated with a heparin/saline flush—Missouri, New York, Texas, and Michigan, 2004–2005. MMWR Morb Mortal Wkly Rep. 2005;54:269–72.
- Centers for Disease Control and Prevention. Exophiala infection from contaminated injectable steroids prepared by a compounding pharmacy—United States, July–Nov 2002. MMWR Morb Mortal Wkly Rep. 2002;51:1109–12.
- Centers for Disease Control and Prevention. Update: delayed onset Pseudomonas fluorescens bloodstream infections after exposure to contaminated heparin flush—Michigan and South Dakota, 2005–2006. MMWR Morb Mortal Wkly Rep. 2006;55:961–3.
- Hsueh PR, Teng LJ, Yang PC, Chen YC, Pan HJ, Ho SW, Nosocomial infections caused by Sphingomonas paucimobilis: clinical features and microbiological characteristics. Clin Infect Dis. 1998;26:676–81.
- Adams WE, Habib M, Berrington A, Koerner R, Steel DH. Postoperative endophthalmitis caused by Sphingomonas paucimobilis. J Cataract Refract Surg. 2006;32:1238–40.
- Kilic A, Senses Z, Kurekci AE, Aydogan H, Sener K, Kismet E, Nosocomial outbreak of Sphingomonas paucimobilis bacteremia in a hemato/oncology unit. Jpn J Infect Dis. 2007;60:394–6.
- Perola O, Nousiainen T, Suomalainen S, Aukee S, Karkkainen UM, Kauppinen J, Recurrent Sphingomonas paucimobilis bacteraemia associated with a multi-bacterial water-borne epidemic among neutropenic patients. J Hosp Infect. 2002;50:196–201.
- Lemaitre D, Elaichouni A, Hundhausen M, Claeys G, Vanhaesebrouck P, Vaneechoutte M, Tracheal colonization with Sphingomonas paucimobilis in mechanically ventilated neonates due to contaminated ventilator temperature probes. J Hosp Infect. 1996;32:199–206.
- Tenover FC, Arbeit RD, Goering RV. How to select and interpret molecular strain typing methods for epidemiological studies of bacterial infections: a review for healthcare epidemiologists. Molecular Typing Working Group of the Society for Healthcare Epidemiology of America. Infect Control Hosp Epidemiol. 1997;18:426–39.
- US Food and Drug Administration. FDA regulation of compounded drugs; 2008 [cited 2008 May 15]. Available from http://www.fda.gov/cder/pharmcomp/default.htm
- Galson SK. Statement before the Senate committee on health, education, labor and pensions hearing on “federal and state role in pharmacy compounding and reconstitution: exploring the right mix to protect patients”; 2003 [cited 2008 Mar 28]. Available from http://www.fda.gov/ola/2003/pharmacycompound1023.html
- US Food and Drug Administration. Guidance for industry; sterile drug products produced by aseptic processing—current good manufacturing practice; 2004 [cited 2008 Apr 2]. Available from http://www.fda.gov/cder/guidance/5882fnl.pdf
- Western States Medical Center v. Shalala, 238 F.3d 1090 (9th Cir. 2001).
- Thompson v. Western States Medical Center, 535 U.S. 357 (2002).
- Harteker LR. Federal court strikes down compounding regulations. Am J Health Syst Pharm. 2001;58:638, 640,643.
- American Society of Health-System Pharmacists. ASHP guidelines on quality assurance for pharmacy-prepared sterile products. Am J Health Syst Pharm. 2000;57:1150–69.
- United States Pharmacopeia. Guidebook to pharmaceutical compounding—sterile preparations. Rockville (MD): The Pharmacopeia; 2008 [cited 2008 20 Nov]. Available from http://www.usp.org/products/797Guidebook
- Kastango ES, Bradshaw BD. United States Pharmocopeia chapter 797: establishing a practice standard for compounding sterile preparations in pharmacy. Am J Health Syst Pharm. 2004;61:1928–38.
- Morris AM, Schneider PJ, Pedersen CA, Mirtallo JM. National survey of quality assurance activities for pharmacy-compounded sterile preparations. Am J Health Syst Pharm. 2003;60:2567–76.
- Candy TA, Schneider PJ, Pedersen CA. Impact of United States Pharmacopeia chapter 797: results of a national survey. Am J Health Syst Pharm. 2006;63:1336–43.
- US Food and Drug Administration. Report: limited FDA survey of compounded drug products 2003. [cited 2008 Mar 28]. Available from http://www.fda.gov/cder/pharmcomp/survey.htm
- Schweitzer SO. Trying times at the FDA—the challenge of ensuring the safety of imported pharmaceuticals. N Engl J Med. 2008;358:1773–7.
- Wood AJ. Playing “kick the FDA”—risk-free to players but hazardous to public health. N Engl J Med. 2008;358:1774–5.
Suggested citation for this article: Maragakis LL, Chaiwarith R, Srinivasan A, Torriani FJ, Avdic E, Lee A, et al. Sphingomonas paucimobilis bloodstream infections associated with contaminated intravenous fentanyl. Emerg Infect Dis [serial on the Internet]. 2009 Jan [date cited]. http://dx.doi.org/10.3201/eid1501.081054
1Data presented in part at the 18th Annual Meeting of the Society for Healthcare Epidemiology of America; Orlando, Florida; April 6, 2008 (abstract 478).
Comments to the Authors
Lessons from the History of Quarantine, from Plague to Influenza A